What Size Bulbs Does a 2002 Volvo S60 Use?
Correct headlight, fog light, and tail light bulb sizes. Sourced from OEM catalog data.
Installation Difficulty
Hard (Tight clearances)
Est. Replacement Cost
$15 - $40 (Halogen) / $30+ (LED)
What Lighting System Does the 2002 Volvo S60 Have?
The 2002 Volvo S60 features an extensive lighting system with 13 bulb positions. It uses halogen technology with H7 LED low beams and 9005 LED high beams in a dual-bulb configuration. The S60 has been available from 2001 to 2018, and the 2002 model falls in the early-generation years.
Can You Put LED Bulbs in a 2002 Volvo S60?
To upgrade the 2002 Volvo S60 headlights to LED, you will need a H7 LED LED kit for the low beams and a 9005 LED LED kit for the high beams. Start with the low beams since they are used most often and have the biggest impact on nighttime visibility. For the fog lights, a H1 LED LED bulb provides a clean white output that pairs well with LED headlights.
How to Replace Bulbs on a 2002 Volvo S60
The H7 bulb uses a spring clip or wire retainer that holds the bulb in the socket. To remove the old bulb, disconnect the wiring harness first, then twist the bulb counter-clockwise and pull it out. Volvo vehicles are known for tight engine bay clearances around the headlight assembly. You may need to remove the air intake duct, battery cover, or wheel well liner to access the bulbs. Budget 30 to 45 minutes per side for your first replacement. When installing the new bulb, avoid touching the glass with bare fingers. Skin oils create hot spots that shorten bulb life. Wear clean gloves or handle the bulb by its plastic base only. The fog lights are accessed from underneath the front bumper. You may need to remove a few plastic clips or screws from the fender liner to reach the H1 LED fog light socket.
Full Upgrade Bundle
Upgrade All 13 Positions at Once
2002 Volvo S60 Complete Bulb Size Chart
| Position | Bulb Size | Shop |
|---|---|---|
Low Beam | H7 LED | Buy H7 LED |
High Beam | 9005 LED | Buy 9005 LED |
Fog Light | H1 LED | Buy H1 LED |
Brake Light | LED Bulb | Buy LED Bulb |
Side Marker | 5008 LED | Buy 5008 LED |
Turn Signal Front | 1157NA LED | Buy 1157NA LED |
Turn Signal Rear | 12496 LED | Buy 12496 LED |
Dome Light | 6411 | Buy 6411 |
License Plate | 2825 | Buy 2825 |
Map Light | 6411 | Buy 6411 |
Parking Light | 2825 | Buy 2825 |
Reverse Light | 7506 | Buy 7506 |
Trunk Light | 6418 | Buy 6418 |
Want to upgrade everything at once?
Shop Complete LED Kit for 2002 Volvo S60How Long Do 2002 Volvo S60 Headlight Bulbs Last?
Standard halogen headlights on the 2002 Volvo S60 have an expected lifespan of 500 to 1,000 hours, which works out to roughly 2 to 3 years of normal use. Signs of a failing halogen bulb include noticeably dimmer output, a yellowish tint compared to the other headlight, or intermittent flickering. At 24 years old, the original bulbs on your S60 are likely overdue for replacement. Even if they still illuminate, reduced brightness significantly impacts nighttime safety. When one headlight burns out, replace both sides at the same time. Bulbs from the same batch age at similar rates, and mismatched brightness is distracting to oncoming drivers.
What Bulbs Are Compatible with the 2002 Volvo S60?
The H7 low beam bulb on the 2002 Volvo S60 is a specific fitment. There are no widely recognized cross-compatible alternatives, so make sure to purchase the exact H7 size. For the high beams, the 9005 is interchangeable with HB3. Using the wrong bulb size can cause improper beam patterns that reduce your visibility and blind other drivers. It can also cause overheating inside the headlight housing, potentially warping the plastic lens or reflector. Always verify the bulb number before purchasing.
2002 Volvo S60 Headlight FAQ
Did Volvo S60 Bulb Sizes Change Over the Years?
Over its production run from 2001 to 2018, the Volvo S60 has seen bulb size changes in the Low Beam, High Beam and Fog Light positions. The 2002 model uses the earlier bulb specification that was in place before the change around 2014. Always verify the exact bulb size for your specific 2002 model year using the chart above, as using the wrong size can result in poor fitment or reduced light output.
Other S60 Years
More from Volvo
Other Vehicles That Use H7 LED Bulbs
These vehicles from other makes also use a H7 LED low beam bulb: